Product ID:T-10/T-100/ST-100 AGGREGATE COMPONENT
MSDS Date:08/14/1998
FSC:5601
NIIN:01-366-4776
Status Code:A
MSDS Number: CLDJC

AMERICAN SAFETY TECHNOLOGIES INC.

565 EAGLE ROCK AVE.
ROSELAND, NJ 07068
US

Emergency Phone: 800-424-9300

Info Phone: 973-403-2600

Preparer: J. HERMELE

Cage: 88444

AMERICAN SAFETY TECHNOLOGIES INC

ROSELAND, NJ 07068 US

Telephone: 973-403-2600

Cage: 88444

(MAY CONTAIN VARIED

CAS: 14808-60-7

RTECS: VV7330000

OSHA PEL 8 HR TWA; 0.1 MG/M3

ACGIH TLV: 8 HR TWA; 0.1 MG/M3

MARBLE (LIMESTONE)

CAS: 1317-65-3

RTECS: EV9580000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

CALCIUM MAGNESIUM CARBONATE

CAS: 16389-88-1

OSHA PEL 5 MG/M3

ACGIH TLV: N.E.

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CANCER HAZARD. CONTAINS SILICA
QUARTZ/SILICON DIOXIDE, WHICH ARE LISTED AS LUNG CARCINOGENS .
EYES: AGGREGATE MAY CAUSE INJURY. SKIN: AGGREGATE ABRASIVENESS MAY
CAUSE IRRITATION OR INJURY. INH ALATION: A NUISANCE PARTICULATE
WITH A LONG HISTORY OF LITTLE ADVERSE EFFECT ON LUNGS AND NO
PRODUCTION OF SIGNIFICANT ORGANIC DISEASE OR TOXIC EFFECT WHEN
EXPOSURES ARE KEPT UNDER REASONABLE CONTROL. INGESTION: NO
SPECIFIC INFORMATION AVAILABLE. SHOULD NOT CAUSE ANY SIGNIFICANT
HEALTH PROBLEMS.
Explanation of Carcinogenicity:SILICON DIOXIDE, SILICA QUARTZ: IARC
GROUP 1, VOLUME 69, PAGE 41, 1997. NTP KNOWN HUMAN CARCINOGEN, NTP
9TH ANNUAL REPORT ON CARCINOGENS, 2000.
Effects of Overexposure:OVEREXPOSURE EFFECTS: IRRITATION, SENSITIZATION
AND DERMATITIS.
Medical Cond Aggravated by Exposure:RESPIRATORY DISEASES.

First Aid:EYES: FLUSH WITH LARGE QUANTITIES OF WATER FOR AT LEAST 15
MINUTES TO REMOVE PARTICULATES. SKIN: WASH WITH MILD SOAP AND
WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION: IF LARGE AMOUNT
IS INGESTED AND VICTIM IS CONSCIOUS, GIVE LARGE QUANTITIES OF
WATER AND INDUCE VOMITING. GET MEDICAL ATTENTION.

Flash Point:N.A.
Lower Limits:N.A.
Upper Limits:N.A.
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . N.A. (CAN BE
USED TO SMOTHER FIRES) (MFR).
Fire Fighting Procedures:WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. MATERIAL IS NON-COMBUSTIBLE.

Spill Release Procedures:USE RESPIRATORY PROTECTION FOR AIRBORNE DUST.
VACUUM OR SCOOP FOR RECOVERY OR DISPOSAL. WETTING SPILL WITH A
WATER SPRAY WILL HELP TO KEEP DUST LEVELS DOWN; USE GOOD
VENTILATION IF POSSIBLE.

Handling and Storage Precautions:USE DUSTLESS SYSTEM OF STORAGE AND
HANDLING. KEEP WELL-VENTILATED.

Respiratory Protection:NIOSH-APPROVED DISPOSABLE HALF-MASK FOR
DUST/MIST IF REQUIRED.
Ventilation:LOCAL EXHAUST AS APPROPRIATE. MECHANICAL VENTILATION IS
RECOMMENDED.
Protective Gloves:LEATHER OR RUBBER GLOVES.
Eye Protection:ANSI-APPROVED CHEMICAL SAFETY GLASSES/DUST-TIGHT GOGGLES
.
Other Protective Equipment:EYEWASH STATION AND DELUGE STATION MEETING
ANSI DESIGN CRITERIA . AN EYEWASH FACILITY SHOULD BE AVAILABLE IN
MATERIAL HANDLING AREA (MFR).
Supplemental Safety and Health

Boiling Pt:B.P. Text:N.A.
Melt/Freeze Pt:M.P/F.P Text:N.A.
Vapor Pres:N.A.
Vapor Density:N.A.
Spec Gravity:2.7
Evaporation Rate & Reference:N.A. (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:VARIOUSLY COLORED CRUSHED STONE; NO ODOR.

Stability Indicator/Materials to Avoid:YES
ACIDS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE AND LOCAL REGULATIONS . NOT CONSIDERED A HAZARDOUS WASTE;
CAN BE USED AS A SOIL SWEETENER.

Toxicological Information:CARCINOGENIC DATA: THIS PRODUCT CONTAINS
SILICON DIOXIDE/SILICA. THE INTERNATIONAL AGENCY FOR RESEARCH ON
CANCER CONCLUDED THERE WAS "SUFFICIENT EVIDENCE IN HUMANS FOR
CARCINOGENICITY OF CRYSTALINE SI LICA IN THE FORMS OF QUARTZ OR
CRYSTOBALITE FROM OCCUPATIONAL SOURCES." THE OVERALL IARC
EVALUATION WAS THAT "CRYSTALLINE SILICA INHALED IN THE FORM OF
QUARTZ OR CRYSTABALITE FROM OCCUPATIONAL SOURCE S IS CARCINOGENIC
TO HUMANS (GROUP 1). NTP HAS CONCLUDED THAT "SILICA, CRYSTALLINE
(RESPIRABLE) MAY REASONABLY BE ANTICIPATED TO BE CARCINOGEN."
CRYSTALLINE SILICA IS NOT REGULATED BY OSHA AS A CARC INOGEN. SINCE
ALL SILICON (ECOLOGICAL)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:TOXICOLOGICAL INFO (CONT'D): DIOXIDE/SILICA IS OF
NON-RESPIRABLE SIZE AND ENCAPSULATED IN THE COATING, NO
OVEREXPOSURE TO AIRBORNE DUSTS IS TO BE EXPECTED. HOWEVER, DURING
REMOVAL BY MECHANICAL ABRASI ON, APPROPRIATE SAFETY PRACTICES
SHOULD BE FOLLOWED TO PREVENT INHALATION OF AIRBORNE DUSTS.

Transport Information:D.O.T. SHIPPING CLASSIFICATION (49 CFR 172.101):
(NOT REGULATED)

SARA Title III Information:SECTION 313 SUPPLIER INFORMATION: THIS
PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 OF EMERGENCY PLANNING AND
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 & 40 CFR 372. THIS INFORMATION
MUST BE INCLUDED ON MSDS COPIED AND DISTRIBUTED FOR THIS MATERIAL:
CHEMICAL NAME, CAS NUMBER, WEIGHT %: NONE LISTED.
State Regulatory Information:CALIFORNIA PROPOSITION 65 INFORMATION:
WARNING! THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM: SILICON DIOXIDE (RESPIRA BLE PARTICLES).